150cc Alien Scooter Photo Manual
*Click on pictures with colored borders for close up pictures.
|
Scooter arrives in crate.
|
***Retrieve front wheel
|
Front wheel spacer |
| |
spacer. |
***Do not lose this!!*** |
|
Close up of front wheel
|
Front View of Scooter. |
Retrieve front wheel for |
| spacer. Cut zip tie. |
|
installation. |
|
Remove spacer in disc
|
Put wheel spacer in front |
Spacer should look like |
| brake pads. |
wheel. |
this in front wheel. |
|
Install wheel. Slide disc
|
Retrieve speedometer |
Install speedometer cable |
| into disc brake pads. |
cable to install on wheel. |
on wheel. |
|
Secure bolt into front
|
|
Battery box. |
| wheel fork. |
|
|
|
Battery and electrolytes.
|
Line up electrolytes with |
Push electrolytes into |
| Wear protective golves! |
sockets on top of battery. |
battery sockets. |
|
Poke holes into top of
|
|
Replace cover. |
| electrolytes to release acid. |
|
|
|
|
Nuts and bolts for batter. |
Place nuts inot position. |
| |
|
|
|
Place bolts into position.
|
|
Remove top front cover to |
| |
|
better access battery compartment. |
|
Flasher
|
Install battery. |
Install battery. |
| |
|
|
|
Attach front panel. Place
|
Place clip nut in position |
|
| clip nuts onto body panel. |
|
|
|
Place clip nut in position
|
|
All four clip nuts in position |
| |
|
|
|
Female end plugs for front
|
|
Connect male end from |
| panel light. |
|
front panel. |
|
Connect both wires.
|
Attach front panel. |
Line front panel up with |
| |
|
clip nuts just installed |
|
Screws and clip nut for
|
Attach front panel with |
|
| panel installation. |
screws. |
|
|
Install windsheld. Attach
|
|
Attach all four clip nuts. |
| clip nut on windshield. |
|
Line windshield up with front panel holes. |
|
Slide clips into holes on
|
|
Insert screws and attach |
| front panel. |
|
windshield. |
|
Attach front panel.
|
Line front panel up and |
Insert screws. |
| |
slide on. |
|
|
|
Place clip nut on bottom |
Line the panel up for installation |
| |
of panel. |
|
|
Attach the screw
|
|
LIne up side panel foot |
| |
|
rest. Screw down (no pre-drilled holes.) |
|
Fasten screws into
|
|
|
| panels |
|
|
|
Fasten passenger foot
|
|
|
| rest. |
|
|
|
Handle bar switches
|
HIgh beam, low beam, |
Kill switch and |
| |
turn signal, horn. |
|
|
Add 10w30 Motor Oil
|
Checking and adding oil. |
Checking and adding oil. |
| |
|
|
|
Checcking and adding oil.
|
Oil and drain screw. |
Oil drain screw. |
| |
|
|
|
Brake fluid container
|
Brake fluid measure. |
Airbox |
| |
|
|
|
Petcock.
|
Petcock. |
Voltage Regulator. |
| |
|
|
|
Voltage Regulator.
|
VIN number. |
Frame number. |
| |
|
|
|
VIN number.
|
Carburetor idle speed |
Adjust carburetor idle |
| |
screw. |
speed screw. |
|
Kick stand. Kills engine.
|
|
|
| |
|
|
|
